This is a response for the following youtube video: (because on youtube it's allowed to write only max. 500 characters in each comments)

HI! I know your problem. I have the same bike.
ALL ORIGINAL AGILITY bikes do the same and need to warm up the engine before start riding below approx. +10 celsius. Because until the engine is not warm enough: if you pull the throttle, maybe the engine will stall. I know that it can be very exasperating. This warm-up period takes about 1-10 minutes depending on the temperature. E.g. in summer it is not necessary...

Why is this problem? In winter conditions the air is too much and the gasoline is not enough. I think the engineers wanted to minimize the fuel consumption&emission, and they thought that most people use their bike over +10 celsius - That's absolutely normal. Over this temperature there is no problem.

What you can do?
There are alternative solutions e.g. covering the air-cooling fan for some minutes in winter but that's not the best, especially, if you forget to remove the covering and the engine will be too hot.

So I recommend you to replace the carb's main jet for a bigger one (try to test how bigger is the best) and use with it at least in winter. I think in summer this bigger main jet is not necessary because of the higher fuel consumption, but I haven't tried it yet, because I'm a hypermiler. Maybe, if I'll use my bike next winter I'll also try a bigger main jet, but only for winter-period.

But, if you haven't had such problems so far, you must have set inproperly the carburetor. Unfortunately I can't help you to repair it in writing, you should try to reset it again properly. If you should not manage to set it, you may ask for an expert's assistance.

Greetings from Hungary

Szerző: gaborjozsef

1 komment

Címkék: kymco agility

A bejegyzés trackback címe:


A hozzászólások a vonatkozó jogszabályok  értelmében felhasználói tartalomnak minősülnek, értük a szolgáltatás technikai  üzemeltetője semmilyen felelősséget nem vállal, azokat nem ellenőrzi. Kifogás esetén forduljon a blog szerkesztőjéhez. Részletek a  Felhasználási feltételekben és az adatvédelmi tájékoztatóban.

anonymous 2011.04.08. 15:04:54

Sticlistul writes:

Thank you verry much for repply , your explanation sounds plausible. What concerns me is that last winter didn't happened , it happened only after I'ved opened the carb. I think that there are some tiny adjustments which neither me or guys from service aren't aware of it. Thanks again from reply and if I find out next winter I will try to reply here with the solution